KERR SonicFill User Manual Manual

14, used. Kerr recommends specifying a service interval at the dental office for a licensed shop to clean, service and check the functioning of the medical device. This service interval should take into account the frequency of use. Service may only be provided by repair shops that …

3, 1 User instructions Dear user, Congratulations on purchasing this Kerr quality product. Following the instructions below will allow you to work smoothly, economically and safely. User instructions 1 …

29, KERR SonicFill ▶ If your coupling system is equipped with a light, please wait for at least 5 seconds before you remove the SonicFill handpiece to prevent damage to the light source. CAUTION Ensure that the SonicFill handpiece is firmly seated on the coupling. The SonicFill handpiece can be…

46, KERR SonicFill 6.6 Care products and systems - Servicing CAUTION Premature wear and malfunctions from improper servicing and care. Reduced product life. ▶ Perform proper care regularly! Preparation methods according to ISO 17664 44 …

42, Consumables required: Cloths for wiping off the medical device. Spray the disinfectant on a cloth, then thoroughly wipe down the medical device and leave the disinfectant to soak in according to the instructions from the disinfectant manufacturer. Note Follow the instructio…

49, KERR SonicFill ▶ Place the product on the SonicFill MULTIflex coupling, and press the spray button for one second. 6.7 Packaging Note The sterilization bag must be large enough for the instrument so that the bag is not stretched. Seal each medical device individually in a…

51, CAUTION Contact corrosion due to moisture. Damage to product. ▶ Immediately remove the product from the steam steriliser after the sterilisation cycle! Note Remove the SonicFill Unidose tip before sterilization. The SonicFill Unidose tips are non-steriliz‐ able.…

33, ▶ Push the SonicFill Unidose tips by hand into the corresponding opening of the SonicFill handpiece using moderate pressure and turn the handpiece in a clockwise direction, screw‐ ing it into the SonicFill tip. 5.4 Removing the SonicFill Unidose Tips ▶ Unscrew the Soni…

37, KERR SonicFill 6.3 Cleaning CAUTION Malfunctions from cleaning in the ultrasonic unit. Defects in the product. ▶ Only clean manually or in a thermodisinfector. Preparation methods according to ISO 17664 35 …

13, CAUTION Swallowing or aspiration of the SonicFill Unidose tip by the patient. ▶ Before each treatment involving the SonicFill handpiece, insert a rubber dam for safety reasons. The following persons are authorized to repair and service Kerr products: ▪ Tec…

48, KERR SonicFill Note If the oil leakage is bothersome, once weekly servicing is sufficient. ▶ Remove the SonicFill Unidose Tips. ▶ Cover the product with the cellulose bag. Preparation methods according to ISO 17664 46 …

41, KERR SonicFill 6.4.1 Disinfection: Manual disinfection - external Kerr recommends the following products based on material compatibility. ▪ CaviCide made by Metrex Preparation methods according to ISO 17664 39 …

26, 4.3 Check the O-rings CAUTION Missing or damaged O-rings. Malfunctions and premature failure. ▶ Make sure that all O-rings are on the coupling and undamaged. Number of available O-rings: 5 First use 24 …

12, CAUTION Injury or damage due to wear. If you notice uneven operating noises, excessive or unexpectedly low vibrations or the SonicFill Unidose tip coming undone. ▶ Stop working and contact service support. Safety 10 …